To All:
Thank you so much for all the great advice, both in the postings and in the PMs.
We reviewed the video, and we followed it closely.
Ya'll are also correct. The oil on the dipstick looked good, but when we opened the drain plug, it was all sludge and some paste! It took 5 gallons of kerosene, scrubbing, and scraping to get the sludge out.
I have received several PMs asking for updates
History:
The couple (our club did not know the couple) moved to the Smoky Mountains in 1988. They purchased the cars as a matched pair in Florida. They were used in parades frequently. When they moved to Tenn, he parked them in the garage and did not drive them. He is not a mechanic, and his automotive repair shop in Florida would not come here to service them. The family never saw Grandaddy drive either car. He was too scared in case "something broke. He always said they were perfect." See pic of Grandaddy as a young man, face blurred out of respect.
Barn Find visit:
The day primarily consisted of work on the Phaeton:
Initial assessment: they are rough, with good bones and no damage, but overall in a bad way.
The couple's church's elders helped by providing water and frequent errands to get supplies (oil, water for radiator, etc). Super nice people!
Like the other posters in this thread said, "focus on the engine." We did that only.
We addressed the Phaeton first -- closest to the garage door and unmolested by "mechanics" -- the true barn find.
Steps:
Fluids:
Removed drain plug = sludge and paste. One guy spent hours cleaning out all the old oil with kerosene. Replaced with fresh detergent 10-30.
Drained and flushed coolant. Clear green (heavy antifreeze). No rust. No leaks.
Electrical->
replaced battery
Disconnected cutout (cover missing); dirt, rust, elements = cutout bad.
Removed cover of starter and inspected; aged but clean and no shorts.
Checked continuity and function of solenoid. Passed. No voltage drop.
Checked for grounds and parasitic drain—no current leaving the battery with points open.
No armored cable—ignition coil wired directly to distributor. Hmmmmm?
Checked Coil -- primary coil bad (internal windings of primary coil = dead short). Replaced with new 6V epoxy-filled, and hooked up correctly, (+) to points. Granddaddy had the (-) side of the coil directly to the distributor.
Replaced distributor with an overhauled spare the club has.
Set points at 0.020"
Checked gap from rotor to lugs 0.035"
Distributor housing had continuity to all four plugs
Checked continuity and for grounds
Timed
Engine->
Removed plugs, inspected, checked ohms, cleaned, and gapped to 0.035"
Changed crushable gaskets
Bore scoped combustion chambers (pics coming; I'm not techy, and we need one of our kids to download the pics). All valves moved and seated. Exhaust valves not original. All 8 have new seats. One seat burned.
Cylinders look ok.
Overall lots of carbon, no rust.
Belt old but flexible.
Hand-cranked engine and thumb test felt compression. Thanks, FordBarn - great tip.
Fuel->
Fule tank empty. With borescope, no rust.
New ethanol-free gas
Fuel bowl leaked; tightened, and that helped some.
Removed fule line to carburetor. Clean gas ran out.
Cycled carburetor and oiled all joints. Bought a spare, but we guessed we should try Grandaddy's. Gas leaked from the bottom, but not badly.
Tried to start, and after 5 or so attempts - nothing.
Checked electrical (our club says 90% of carburetor problems are electrical)
No spark. No spark when the ignition cable was held next to a ground. Checked, and the ignition cable was bad - no continuity. Swapped with a new one.
Tried to start with a split-open distributor cap; we saw spark, and as we were not getting a boom and as we all started to look at one another --
putt putt vroooomm.
She started!
Carb linkage cycled. It works!
Smoke at manifold (leak likely at gasket from loose nuts). WD-40 sprayed on manifold - no change in RPM.
Collective amazement. Handshakes. Family crying.
We were actually kinda surprised.
One guy said, "Let's drive it around the yard." And asked permission from family. They nodded, because they could not speak.
RHD A Models have different pedal configurations. We did not know if the shifting pattern was different - it is NOT.
She drove well. No smoke; stopped when the brakes were applied; clutch soft but worked; she is alive! The 7-tooth steering had excessive play. We noticed a zerk fitting on the fill plug.
On the next visit, we will replace the cowl, clean her, and replace her distributor after a club member rembuilds Granddaddy's.
The family started hugging all these old, sweaty guys.
Great day for a Model A!
Next visit will be for the Roadster. One club member pulled the plugs and another borescoped it. The exhaust valve is stuck in the
OPEN position. PB Blaster, WD-40, a wooden dowel, a curse word, and a kicked tire all could not get that valve down. We will tackle her on the next visit.
I will keep you posted.
Please, please critique us! What should we have done differently? What did we do wrong? What did we not do that we should have?
Ya'll please share your knowledge and experience.
We do not have thin skin.
We are just trying to help a family and resurrect two forgotten ladies.
With Much Gratitude,
Diastole
PS:
How do we unstick an exhaust valve from the open position?
Here is a video of the first moment this Model A saw the light of day since 1988 (38 years)
https://youtu.be/4P2TPc6jXho?si=Z8Yoi5Fn_ChMKtv2